Watlow Electric Gateway & DeviceNet Guide de l'utilisateur

0600-0072-0000 Rev. A Made in the U.S.A.November 2010 User’s GuideRegistered Company Winona, Minnesota USA ISO 9001TOTAL3 Year WarrantyCUSTOMERSATIS

Watlow EZ-ZONE® RM A M odule • 7 • Chapter 2 Install and Wire DimensionsModule Removal Clearance Straight ConnectorsModule Removal Clear

Watlow EZ-ZONE® RM A M odule • 8 • Chapter 2 Install and Wire Dimensions(2.03 in)51.56 mm(.66 in)16.76 mm(2.31 in)58.67 mm(.69 in)17.53 mm(

Watlow EZ-ZONE® RM A M odule • 9 • Chapter 2 Install and Wire Power SuppliesDSP30+ +--L NDC LODC OK123 45 653.00 mmDSP302.087 in91.00 mm3

Watlow EZ-ZONE® RM A M odule • 10 • Chapter 2 Install and Wire RMA Installation and Removal on a DIN RailModular Backplane ConnectorThe pict

Watlow EZ-ZONE® RM A M odule • 11 • Chapter 2 Install and Wire Removal of the Modular Back-plane ConnectorA module can be removed from the M

Watlow EZ-ZONE® RM A M odule • 12 • Chapter 2 Install and Wire Access Module (RMAx-Axxx-xxxx)Slot A Slot B Slot D Slot E Terminal Function C

Watlow EZ-ZONE® RM A M odule • 13 • Chapter 2 Install and Wire Slot ASlot ESlot DSlot B All Modules - Front View -Standard Connector9899

Warning: çUse National Electric (NEC) or other country-specific standard wiring and safety practices when wiring and connecting this controller to a

Watlow EZ-ZONE® RM A M odule • 15 • Chapter 2 Install and Wire Terminal Signal FunctionV+ V+ DeviceNet™ powerCH CAN_Hpositive side of Device

Watlow EZ-ZONE® RM A M odule • 16 • Chapter 2 Install and Wire Profibus DP Communications485 T-/R-+5Vdc Voltage PotentialVPBADGtrBBAtrASlot

Safety Information We use note, caution and warning symbols throughout this book to draw your attention to important operational and safety informati

Watlow EZ-ZONE® RM A M odule • 17 • Chapter 2 Install and Wire Connecting and Wiring the ModulesRM System ConnectionsComponents of a RM syst

Watlow EZ-ZONE® RM A M odule • 18 • Chapter 2 Install and Wire - A+ Bcom- A+ Bcommonpower- A+ BcommonpowerpowerpowerEZ-ZONE PM EZ-

Watlow EZ-ZONE® RM A M odule • 19 • Chapter 2 Install and Wire Conventions Used in the Menu PagesTo better understand the menu pages that fo

Watlow EZ-ZONE® RM A M odule • 20 • Chapter 2 Install and Wire Page under the Backup Menu.For parameters listed as float notice that only on

Watlow EZ-ZONE® RM A M odule • 21 • Chapter 3 Operations PageChapter 3: Operations Page3Access Module Operation Page Parameters[dLog][oPEr] D

Watlow EZ-ZONE® RM A M odule • 22 • Chapter 3 Operations PageAccess Module • Operations PageDisplay Parameter Name DescriptionRange

Watlow EZ-ZONE® RM A M odule • 23 • Chapter 3 Operations PageAccess Module • Operations PageDisplayParameter Name DescriptionRange

Watlow EZ-ZONE® RM A M odule • 24 • Chapter 4 Setup PageChapter 4: Setup Pages4Access Module Setup Page ParametersTo navigate to the Setup P

Watlow EZ-ZONE® RM A M odule • 25 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 26 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

• Your P.O. number• Detailed description of the problem • Any special instructions• Name and phone number of person returning the product.2. Prior ap

Watlow EZ-ZONE® RM A M odule • 27 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 28 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 29 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 30 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 31 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 32 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 33 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 34 • Chapter 4 Setup Page Access Module • Setup PageDisplayParameter nameDescriptionRange DefaultModbus Re

Watlow EZ-ZONE® RM A M odule • 35 • Chapter 5 Factor y PageChapter 5: Factory Pages5Access Module Factory Page ParametersNote:Some of these m

Watlow EZ-ZONE® RM A M odule • 36 • Chapter 5 Factor y Page Access Module • Factory PageDisplayParameter NameDescriptionRange DefaultModbu

Watlow EZ-ZONE® RM A M odule • 1 • Table of ContentsTCTable of ContentsChapter 1: Overview . . . . . . . . . . . . . . . . . . . . . . . . .

Watlow EZ-ZONE® RM A M odule • 37 • Chapter 5 Factor y Page Access Module • Factory PageDisplayParameter NameDescriptionRange DefaultModbu

Watlow EZ-ZONE® RM A M odule • 38 • Chapter 5 Factor y Page Access Module • Factory PageDisplayParameter NameDescriptionRange DefaultModbu

Watlow EZ-ZONE® RM A M odule • 39 • C hapter 6 Features6Chapter 6: RMA FeaturesDimensions . . . . . . . . . . . . . . . . . . . . . . . . .

Watlow EZ-ZONE® RM A M odule • 40 • C hapter 6 FeaturesSaving And Restoring User SettingsRecording setup and operations parameter settings fo

Watlow EZ-ZONE® RM A M odule • 41 • C hapter 6 Featureswith a password would have visibility restricted by the Read Lockout Security [rloC] .

Watlow EZ-ZONE® RM A M odule • 42 • C hapter 6 FeaturesRTC is required to use this feature. As an example, if the Power Off Time were set to

Watlow EZ-ZONE® RM A M odule • 43 • C hapter 6 FeaturesSoftware ConfigurationUsing EZ-ZONE® Configurator SoftwareTo enable a user to configur

Watlow EZ-ZONE® RM A M odule • 44 • C hapter 6 FeaturesIn the previous screen shot the RMA is shown high-lighted to bring greater clarity to

Watlow EZ-ZONE® RM A M odule • 45 • C hapter 6 FeaturesLastly, when the configuration is complete click the "Finish" button at the

Watlow EZ-ZONE® RM A M odule • 46 • C hapter 6 FeaturesFunction Block DescriptionsEach of the next several pages graphically shows each of th

Watlow EZ-ZONE® RM A M odule • 2 • Table of ContentsChapter 7: RMA Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . 49EZ

Watlow EZ-ZONE® RM A M odule • 47 • C hapter 6 FeaturesDiagnostics FunctionDevice Name : EZ-ZONE RMDevice Status : OK, FailHardware ID : 25 (

Watlow EZ-ZONE® RM A M odule • 48 • C hapter 6 FeaturesVariable FunctionRanges specified in units or degrees F if expressed in degrees C, ran

Watlow EZ-ZONE® RM A M odule • 49 • Chapter 7 RMA Communica tionsEZ-ZONE RMA & CommunicationsWith the introduction of the first Programma

Watlow EZ-ZONE® RM A M odule • 50 • Chapter 7 RMA Communica tionsparameter, therefore, within the user program when writing a new value to Mo

Watlow EZ-ZONE® RM A M odule • 51 • Chapter 7 RMA Communica tionsthe front panel for six seconds to go the the Setup Menu.2. Push the up or d

Watlow EZ-ZONE® RM A M odule • 52 • Chapter 7 RMA Communica tionsperature units. The upper display shows [```f] and lower display shows [`C_f

Watlow EZ-ZONE® RM A M odule • 53 • Chapter 7 RMA Communica tionsbit assembly member there is also a Compact Class of the assembly. The need

Watlow EZ-ZONE® RM A M odule • 54 • Chapter 7 RMA Communica tionsApplication Note:Assume that in the following graphic there are 4 RMC module

Watlow EZ-ZONE® RM A M odule • 55 • Chapter 7 RMA Communica tionsLink Status IndicatorSteady Off Not pow-ered, unknown link speedIf the devic

Watlow EZ-ZONE® RM A M odule • 56 • Chapter 7 RMA Communica tionsModule Status (MOD)Indicator LED DescriptionOff No power is applied to the d

Watlow EZ-ZONE® RM A M odule • 3 • Chapter 1 Over viewChapter 1: Overview 1The EZ-ZONE® Rail Mount Access module (RMA) takes the pain out of

Watlow EZ-ZONE® RM A M odule • 57 • Chapter 7 RMA Communica tions8. Push the up or down arrow key to enable or dis-able the quick connect fe

Watlow EZ-ZONE® RM A M odule • 58 • Chapter 7 RMA Communica tionsProfibus DP RMA LED IndicatorsViewing the unit from the front and then looki

Watlow EZ-ZONE® RM A M odule • 59 • Cha pter 8 A ppendixChapter 8: AppendixModbus - User Programmable Memory BlocksAssembly Denition Address

Watlow EZ-ZONE® RM A M odule • 60 • Cha pter 8 A ppendixModbus Default Assembly Structure 40-119Pointer 1 = 0 & 1Closed Loop Set Point 1R

Watlow EZ-ZONE® RM A M odule • 61 • Cha pter 8 A ppendixModbus Default Assembly Structure 120-199Pointer 41 = 0 & 1UndefinedRegisters 120

Watlow EZ-ZONE® RM A M odule • 62 • Cha pter 8 A ppendixRMA / RME CIP Implicit Assembly DefaultsCIP Implicit Assembly StructureAssemblyMember

Watlow EZ-ZONE® RM A M odule • 63 • Cha pter 8 A ppendixRMH / RMS / RML CIP Implicit O to T Assembly DefaultsAssemblyMembersAssemblyClass, I

Watlow EZ-ZONE® RM A M odule • 64 • Cha pter 8 A ppendixRMH / RMS / RML CIP Implicit T to O Assembly DefaultsAssemblyMembersAssemblyClass, In

Watlow EZ-ZONE® RM A M odule • 65 • Cha pter 8 A ppendixRMC CIP Implicit Assembly DefaultsAssemblyMembersAssemblyClass, Instance, AttritbuteR

Watlow EZ-ZONE® RM A M odule • 66 • Cha pter 8 A ppendixAs can be seen on the previous page the RMC module is the only RM module that default

Watlow EZ-ZONE® RM A M odule • 4 • Chapter 1 Over viewA Conceptual View of the RM SystemThe flexibility of the RM’s software and hardware al

Watlow EZ-ZONE® RM A M odule • 67 • Cha pter 8 A ppendixAssemblyClass, Instance, AttributeModuleAvailabilty31 30 29 28 27 26 25 24 23 22 21 2

Watlow EZ-ZONE® RM A M odule • 68 • Cha pter 8 A ppendix15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0Input error statusLoop error statusTune status15

Watlow EZ-ZONE® RM A M odule • 69 • Cha pter 8 A ppendixAssemblyClass, Instance, AttributeModuleAvailabilty31 30 29 28 27 26 25 24 23 22 21 2

Watlow EZ-ZONE® RM A M odule • 70 • Cha pter 8 A ppendix15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 015 14 13 12 11 10 9 8 7 6 5 4 3 2 1 015 14 13 12

Watlow EZ-ZONE® RM A M odule • 71 • Cha pter 8 A ppendixRMA SpecificationsLine Voltage/Power• 20.4 to 30.8Vı (ac/dc), 50/60Hz, ±5 percent•

Watlow EZ-ZONE® RM A M odule • 72 • Cha pter 8 A ppendixEZ-ZONE Rail-Mount Access Module Ordering InformationCode NumberUSB Device Configurati

Watlow EZ-ZONE® RM A M odule • 73 • Cha pter 8 A ppendixIndex[`Ad;d] DeviceNet Address 27[Ad;M] Modbus Address 25[Ai;nb] Implicit Input Ass

Watlow EZ-ZONE® RM A M odule • 74 • Cha pter 8 A ppendixMModbusUser Programmable Memory Blocks 49Assembly Denition Addresses 49Assembly Wo

Watlow EZ-ZONE® RM A M odule • 75 • Cha pter 8 A ppendixDeclaration of Conformity EZ Zone Series RM WATLOW an ISO 9001 approv

Watlow EZ-ZONE® RM A M odule • 76 • Cha pter 8 A ppendixHow to Reach UsCorporate HeadquartersWatlow Electric Manufacturing Company12001 Lackl

Watlow EZ-ZONE® RM A M odule • 5 • Chapter 1 Over viewModule OrientationThe picture below reflects a front view of an RMA module. Like all R

Watlow EZ-ZONE® RM A M odule • 6 • Chapter 1 Over viewEZ-ZONE RM-Access Module - System DiagramZone SelectionButtonSProtocol of Choice - E